INFLUENCE OF FLUOROCARBON COMPOUNDS ON ANTI-FRICTION AND OPPOSITE PROPERTIES OF TRICOMPOUNDS
DOI:
https://doi.org/10.18372/0370-2197.1(102).18432Keywords:
effectiveness of oil action, carbonofluoride additives, oils, lubricating action, graphite, molybdenum disulfide, fluorocarbon compoundsAbstract
The results of the study of the influence of fluorocarbon compounds of the type (СХ)n on the antifriction and antiwear properties of tribocompounds are presented. It is shown that in conditions of extreme lubrication of gears and bearings, these compounds have good prospects for use as additives and additives to oils. Mechanisms of lubricating action and some examples of practical application are considered. The developed methods of using carbonofluorides include running-in of friction nodes in environments that contain carbonofluorides, introduction of carbonofluoride additives in oils, plastic lubricants, lubricating-cooling and hydraulic fluids. Approbation of these methods in friction nodes of gas turbine engines (GTD) showed the prospect of their wide use in aviation technology. The most important results of the test are that in the presence of carbonofluorides, the service life and maximum allowable contact stresses of rolling bearings and gears can be significantly increased, and after the introduction of carbonofluorides, the friction nodes become less sensitive to the quality of lubricants.
References
Stosk A.J. Graphite Molybdenum Disulfide & PTFE-A Comparison. Lubr. Eng. 19 333-338 (1963).
Fusaro D. Sliney H. Graffhide Fluoride (CFx )n -A New Solid Lubricant. ASLE Trans., 13, pp. 56-65, 1970.
Taku V. The Lubrication of bevel gears. Bull. ASME, 1964, vol. 7, No. 25, p. 130-138.
Rudorff W. Rudorff G. The Catalytic Influence of Hydrofluoric Acid on the Formation of Carbon Monofluoride Chem. Ber. 80. pp. 413-417. 1947.
Ruuf O. Bretschneider O. Ebert F. The Reactions Products of Various Forms of Carbon with Fluoride. 2. Carbon Monofluoride Z. Anorg.
Allgem. Chem. 217 pp. 1-19 1934.
Increasing the durability of friction nodes by using carbon fluorides /N.D.Kuznetsov, D.G.Gromakovsky, L.I.Kuksyonova et al.// Vestn. machine engineering, 1987. - No. 8.- pp. 13-16.
Melnyk V.B. Lubricating effect of oils with carbonofluoride additives under non-stationary modes of friction/Melnyk V.B., Mnatsakanov R.G., Fedina V.P. // Problems of friction and wear: coll. of science works K: NAU, 2007. No. 47. P. 250-267
Melnyk V.B. Adsorption-chemical model of the mechanism of the lubricating action of carbonofluoride additives/V.B. Melnyk, V.V. Nechiporuk// Problems of friction and wear: coll. of science works. K: NAU, 2014. No. 62. P. 104-108.
Melnyk V.B. The influence of carbon fluoride additives on the quality indicators of the lubricating action of lubricants during the running-in process of gears. /Melnyk V.B., Leusenko Yu.S.// Problems of friction and wear, 2013, Vol. 1(60). P. 74-78.
Melnyk V.B. Evaluation of the effectiveness of the oil action of oils with carbonofluoride additives in non-stationary modes of friction / Melnyk V.B., Leusenko D.V., Mamai B.M. // Problems of friction and wear. 2023. Issue No. 4(101). WITH.
Devine M.J. Lamson E.R. Boven J.H. Inografik Solid Film Lubricants, Journal of Chem. & Eng., Data 6, pp. 79-82 (1961)
V.B. Melnyk, D.G. Gromakovsky, O.M. Bilyakovich. The mechanism of lubricating effect of carbonofluoride additives // International. NTK "Improvement of structural and operational parameters of cars and machines" (Kyiv, 1995): Abstracts of add. -K., 1995. -95p.
Cadman P. Gossedge G.M. The Chemical Nature of Vetal PTFE Tribological Interactions as Studied by XPS. - Wear, 54, pp. 211-215, 1979.
Fusaro, R. L. Lubricating and Wear Mechanisms for a hemisphere Sliding on Polyimide-Bonded Graphite Fluoride Film. NASA TP 1524 (1979).
Ishikawa, T.; and Shimada, T.: Application of Polycarbon Monofluoride. Presented at the Fluorine Symposium, Moscow, 1969.
